Tuesday 27 September 2016

It's time to Dye........

After a busy season of shows and workshops, stocks of felting texture goodies were running low at Calonwlân Felt HQ. 


So it was time to dye..... truly a labour of love:

here's how this Blue-faced Leicester fleece


was transformed into this


First, I found a source of woolly loveliness: a local award winning farm, The Hope, Llandeilo, Carmarthenshire. 

The fleece was 'skirted', which means removing all the dirtiest parts. I laid it out on a plastic sheet on the lawn to do this.

The best parts of the fleece for my purposes are the curliest and softest. This is the shoulder and back area of the sheep, towards the rear the curls tend to be matted or part-felted from all the friction they receive from the sheep lying about in the grass:-) I avoid using these bits.


ooh it's sooo soft!


Washing the fleece:

I divided up the best bits into portions, enough to each fit in a washing-up bowl or bucket. First, each bowl was filled with very hot water with a splash of gentle detergent, I find washing up liquid is more than adequate. A portion of fleece was gently lowered into the hot soapy water. Wearing rubber gloves or using tongs, the wool was pushed down so it was completely covered, with minimum agitation, to avoid felting the wool fibres. Normally I try my hardest to get fleece to felt when I am making a textile but during the washing/dyeing process I am trying my utmost to avoid any felting!



It was soaked for around 15 - 20 minutes. This de-greases the fibres. During this time the dirt also separates away from the fibres. If the water gets cold the grease will re-attach to the fibres. The fibres were removed (carefully) while the water was still warm. The dirty water was tipped away and the bowl filled with fresh water which was as close to the temperature the fibres were when they were removed from the dirty water. 

Note: A contrast of water temperature at this point will cause the fibres to felt! 

The fibres were gently submerged in the rinse water and were allowed to sit for a minute or two. This was repeated until the water became clear. The fibres were placed in a net laundry bag and the top secured. The bags were put through the spin cycle in the washing machine to remove excess water. 

Dyeing:

The fleece was dyed while it was damp to allow the dyes to be taken up by the fibres more evenly.



Acid dyes are used to dye protein fibres (wool). The brands Landscape and Gaywool are my preferred dyes, with a fixative already integrated in the powder. Additionally, heat is required to fix the dyes. I use an old tea urn. The urn is half filled with cool to tepid water.

A dye stock was mixed and applied to the fleece. Minimal amounts were used, otherwise there would be much rinsing of un-absorbed, excess dye to do later. Once the fibres were completely covered in dye solution they were placed in a plastic bag and once the bag was sealed it was placed on the surface of the water in the urn. 

The water (together with the wool packages) was slowly brought up to near boiling point and then the wool packages were left to simmer for 30-40 minutes. Note again: A contrast of water temperature at this point will cause the fibres to felt. The bags of fibre were left in situ to cool slowly overnight. 

The fibre was then rinsed gently in cool water (same method as when washing the fleece earlier) until the water was clear. Remember, any contrasting temperature would cause the fibres to felt. Moving the fibres about when hot may cause felting also. The dyed fibre was put in net bags again and put through the spin cycle in the washing machine. The fibres were left out to dry in the net bags on the washing line. 

When dry, the fibres were admired, weighed and packaged up, labels applied and phew, I then collapsed in a happy heap :-)



sometimes I had some help with the packaging up.....




Happy days.........



Now comes the best bit, 
what to do with all the lovely fibre goodies? 


Well, why not come along to a workshop to find out.......

more details  click here


 What are you waiting for?


Copyright Sarah Enoch 2016

No comments:

Post a Comment